电动增压补气消除柴油机瞬态加速冒烟的试验

将自行开发的、适用车载24V电源的电动增压补气系统在一台490QDI柴油机上进行了实验研究.实验工况包括起始负荷分别为0和40N.m的加载加速的瞬态工况以及1400r·min-1、60N·m,1600 r·min-1、90N-m和1800 r.min-1、120N·m 3种低转速、大扭矩稳态工况,针对以上工况分别进行了有无电动增压补气的实验.试验结果表明,有电动增压补气的柴油机同原机相比,零负荷加载加速时的微粒排放降低达70%以上,瞬间输出功率最大可提高54.5%;在稳态工况时,HC、CO排放都随着电机转速的升高而降低,最大减少量分别达到66.7%和75.O%;波许烟度平均减小50%以上.此外,加速补气对提高燃油经济性也有一定效果,比油耗最大能降低7.46%.     

Combination of biodiesel-ethanol-diesel fuel blend and SCR catalyst assembly to reduce emissions from a heavy-duty diesel engine

In this study, the efforts to reduce NOx and particulate matter （PM） emissions from a diesel engine using both ethanol-selective catalytic reduction （SCR） of NOx over an Ag/Al2O3 catalyst and a biodiesel-ethanol-diesel fuel blend （BE-diesel） on an engine bench test are discussed. Compared with diesel fuel, use of BE-diesel increased PM emissions by 14% due to the increase in the soluble organic fraction （SOF） of PM, but it greatly reduced the Bosch smoke number by 60%-80% according to the results from 13-mode test of European Stationary Cycle （ESC） test. The SCR catalyst was effective in NOx reduction by ethanol, and the NOx conversion was approximately 73%. Total hydrocarbons （THC） and CO emissions increased significantly during the SCR of NOx process. Two diesel oxidation catalyst （DOC） assemblies were used after Ag/Al2O3 converter to remove CO and HC. Different oxidation catalyst showed opposite effect on PM emission. The PM composition analysis revealed that the net effect of oxidation catalyst on total PM was an integrative effect on SOF reduction and sulfate formation of PM. The engine bench test results indicated that the combination of BE-diesel and a SCR catalyst assembly could provide benefits for NOx and PM emissions control even without using diesel particle filters （DPFs）.     

Effects of EGR,swirl augmentation techniques on combustion of biodiesel/ethanol and their blends in a diesel engine

The diminishing resources and continuously increasing cost of petroleum in association with their alarming pollution levels from diesel engines have caused an interest in finding alternative fuels to diesel which are renewable and sustainable. Emission control and engine efficiency are two most important parameters in current engine design. The impending introduction of emission standards such as Euro IV and Euro V is forcing the research towards developing new technologies for combating engine emissions. The classification of Euro IV and V norms is applicable to heavy-duty engines in Europe, where as Euro 5 is applicable to light-duty engines. This paper presents the effects of exhaust gas recirculation (EGR), swirl augmentation techniques and ethanol addition on the combustion of Honge oil methyl ester (HOME) and its blends with ethanol in a diesel engine. From the experimental work conducted, it is found that the combustion of HOME plus up to 15% ethanol blend in a diesel engine operated with optimised parameters of injection timing 23° Before Top Dead Centre and compression ratio 17.5 results in acceptable combustion emissions and improved brake thermal efficiency (BTE). The addition of ethanol increased BTE with reduced hydrocarbons (HCs), CO and smoke emissions. However, NO _x emissions increased dramatically. Use of appropriate EGR reduces NO _x to acceptable levels. The implementation of swirl augmentation techniques further resulted in increased BTE and considerable reduction in tail pipe emissions such as smoke, HCs, CO and NO _x . The effect of swirl by providing grooves on the piston was taken into consideration to find the overall biodiesel engine performance, which gives scope for further studies.     

大力推广清洁能源——甲醇(M15)汽油

随着国际原油价格持续高位运行,实施能源的多元化战略已是当前世界各国政府做出的重要抉择.我国是一个缺油少气、相对富煤的国家,合理、高效、节能、安全的发展煤基替代燃料是我国能源发展的惟一出路,甲醇汽油是车用燃料替代,是新能源的重要组成部分.本文对此进行了论述.     

EGR率对农用单缸柴油机燃用生物柴油的NOx与PM排放特性影响分析

单缸柴油机作为小型农用机械不可或缺的动力源,在使用过程中会产生大量污染物.其中氮氧化合物（NO_x）和颗粒（PM）是气溶胶的主要组成部分,对大气环境造成了严重污染.为有效改善农用单缸柴油机NO_x和PM排放,本研究通过添加生物柴油对柴油进行改质以及采用机内EGR净化技术两种方案,测量了柴油机分别燃用柴油B0,生物柴油调合燃料B20、B50在不同EGR率下的NO_x和PM排放.结果表明,采用EGR技术能够明显改善柴油机的NO_x排放,但同时会引起碳烟排放的增加.通过在柴油中添加生物柴油能够在一定程度上降低碳烟排放,其中高负荷、大EGR率条件下的改善最为明显.在2000 r·min^-1、75%负荷,EGR率为30%时,燃用B50的碳烟排放与燃用B0相比降低了47.3%.总体上柴油中添加生物柴油与EGR技术共同作用能够有效降低柴油机高负荷工况时的颗粒排放总数量.     

车辆冷却系统高原热平衡性能研究

目的分析海拔高度(大气压力)、环境温度、冷却液温度以及冷却风量等对车辆冷却系统高原散热性能的影响。方法采用模拟试验与仿真相结合的方法。结果海拔升高1000 m,发动机水套散热量平均增加约5.3%;冷却液温度升高10℃,发动机水套散热量平均降低约14.5%;海拔升高1000 m,若保持发动机热平衡状态不变(出口冷却液温度恒定),散热器入口冷却空气流量需增大约8.8%。结论以发动机热平衡状态保持恒定为目标,计算得到了散热器冷却风量随发动机转速、负荷以及海拔高度的变化MAP图,为高原地区车辆冷却系统匹配设计以及优化提供了参考。     

内燃机排放污染物控制技术研究

根据内燃机排放的废气中有害成分的形成机理 ,通过采取控制燃烧、控制燃料、废物再循环、安装设施及更改发动机设计等方法 ,使内燃机污染物排放得以控制     

柴油车排气微粒后处理器的研究

通过同种典型微粒过滤器的比选试验,表明高效袋式消烟器微粒捕集效率最高.其结构简单,成本低,耐热性好,因此具有很好的推广价值.如果应用在公路隧道中,能降低隧道内能见度的影响,具有较大的开发前景.      

涡喷消防车在化学事故中的抢险救援功能

我国化学工业中的有毒气体的泄漏 ,化学品爆炸、失火等特种灾害的发生频度随化学工业的发展速度而同步增长。涡喷消防车是一种特大功率的气体、洗消剂、灭火剂的喷射平台 ,在化学事故的抢险救援中 ,对吹散、稀释、洗消事故现场的有毒气体 ,强制通风、驱散有毒烟雾和火场降温有独特功能 ,有利于赢得抢险救援的宝贵时间。在防毒抢险和消防救援中 ,在保护人民生命安全和消除毒害及爆炸事故方面有其重要作用。     

聚烯烃类废塑料热分解技术中催化剂的选择和机理初探

研究使用不同催化剂情况下聚烯烃类废塑料热分解回收燃油的技术,并对废塑料的热分解机理进行了探讨．结果表明,自制的含大孔径分子筛的ＮＬＧ系列催化剂具有较好的催化性能,在裂解温度４３０℃,催化温度为３６０℃情况下,热分解后油产率为８７．５％,油品中汽油馏分达４１．３％,辛烷值为８８．３,每ｔ生产成本仅１２０００元左右,循环使用２０５余次后,仍保持良好的催化性能．